VW Touran manuals

Volkswagen Touran Service Manual: Refrigerant Circuit Pipes and Hoses

  Caution
Non-approved tools or materials such as leak sealing additives can cause damage or malfunctions in the system.
Only use tools and materials approved by the manufacturer.
The warranty is voided if non-approved tools or materials are used.
All components of the refrigerant circuit submitted for quality observation are always to be sealed (use original sealing caps of original part).
Replace damaged or leaking components of refrigerant circuit. Refer to → Chapter "Components, Replacing".
To date, the original parts (compressor, reservoir, receiver/dryer, evaporator and condenser) have been filled with nitrogen gas. This charge is being gradually discontinued. There is little or no pressure equalization when removing the sealing plugs from the original part.
The mixture of refrigerant oil and refrigerant r134a corrodes certain metals (e.g. copper) and alloys and dissolves some hose materials. Therefore use original replacement parts only.
Pipes and hoses are joined by threaded connections or special plug connectors.
  Note
Observe specified torque for threaded connections, use appropriate release tools for plug connectors.
   
O-Ring
  Caution Non-approved tools or materials such as leak sealing additives can cause damage or malfunctions in the sys ...

Pressure Relief Valve
  Caution Non-approved tools or materials such as leak sealing additives can cause damage or malfunctions in the sys ...

Other materials:

Volkswagen Touran Owners Manual. Checking coolant level and refilling coolant
Fig. 177 In the engine compartment: mark on the coolant expansion tank Fig. 178 In the engine compartment: coolant expansion tank cap First read and observe the introductory information and safety warnings The warning lamp for the engine coolant will light up if the engine coolant leve ...

Volkswagen Touran Service Manual. Run-Flat Tire PAX, Tire Inflation
When filling tires, pay special attention to the following points:   After mounting the tires with inserted valve insert, fill with air. At 1 bar (14.5 psi), check whether both beads are seated correctly. ...

© 2016-2025 Copyright www.vwtouran.net | 0.0244