Volkswagen Touran Service Manual: Battery, Charging with Battery Charger -VAS5095A-
Special tools and workshop equipment
required |
Battery Charger -VAS5095A- |
WARNING
Risk of injury. Follow all Warnings and Safety
Precautions. Refer to
→ Chapter "Warnings and Safety Precautions". |
|
Caution
While charging, always set the battery type to 2.4
V/C (Volts/Battery Cell)! This applies to all batteries. |
|
Note
The battery temperature must be at least 10 C (50 F). |
WARNING
Batteries that have a light yellow visual indicator
do not have to be tested or charged. Jump starting must
not be used! |
There is a risk of explosion during testing,
charging or jump starting. |
These batteries must be replaced. |
|
|
Turn off the ignition and all electrical consumers. |
|
Check the battery type setting on the battery type selector.
Refer to
→ Chapter "Battery Charger -VAS5095A- Device Description".
It must be set to 2.4V/C (Volts/Cell). |
|
Clamp the red charging clamp "+" of the charger to the
positive battery terminal. |
Note
In the case of vehicles with a start/stop function and an
installed Battery Monitoring Control Module -J367-, the black
charging clamp "-" must be connected to the body ground. The
start/stop system will malfunction if it is connected to the
negative terminal on the battery. |
|
Connect the black charging clamp "-" of the charger to the
negative battery terminal. |
|
Switch on the battery charger. Refer to
→ Chapter "Battery Charger -VAS5095A- Device Description". |
Charge current displays. Refer to
→ Fig. ""Battery Charger -VAS5095A- ""-2-
and -3- light up yellow. When only
the yellow LED -3- is lit, the
battery is partially charged (approximately 90%). |
If the green LED. Refer to
→ Fig. ""Battery Charger -VAS5095A- ""-4-
is also lit, the charger has switched to the charge sustain
function. The battery is charged. |
|
Switch off the charger. Refer to
→ Chapter "Battery Charger -VAS5095A- Device Description". |
|
Remove the charger clamps from the battery terminals. |
|
|
|
WARNING
Risk of injury. Follow all Warnings and Safety
Precautions. Refer to
→ Chapter "Warnings and Sa ...
WARNING
Risk of injury. Follow all Warnings and Safety
Precautions. Refer to
→ Chapter "Warnings and Sa ...
Other materials:
Volkswagen Touran Owners Manual. Warning and indicator lamps
Fig. 152 Instrument cluster display: CCS
status display
First read and observe the introductory information
and safety warnings
Lit up
Possible cause
Cruise control system (CCS) controls the speed.
Several warning and indicator l ...
Volkswagen Touran Owners Manual. Running-in
First read and observe the introductory
information and safety warnings Please follow the regulations concerning
running-in of new parts.
Running in a new engine
A new engine needs to be run in during the first 1,500 km. During its first
few hours of running, the internal friction in the e ...
© 2016-2024 Copyright www.vwtouran.net | 0.0252