Volkswagen Touran Service Manual: Evacuating and Charging Valve with Schrader Valve
Special tools and workshop equipment
required |
Torque Wrench 1783 - 2-10Nm -VAG1783- with Torque Wrench
1783 - 1/4" Drive Ratchet -VAS6234- |
WARNING
There is a danger of ice-up. |
Refrigerant will leak out if refrigerant circuit is
not discharged. |
Refrigerant must be extracted before opening
refrigerant circuit. If refrigerant circuit is not
opened within 10 minutes of extraction, pressure may
form in refrigerant circuit due to evaporation. Extract
the refrigerant once more. |
|
Only valves and connections that are resistant to
refrigerant R134a and refrigerant oil must be installed. |
Different connections (outer diameter) for high pressure and
low pressure side. |
Always screw on sealing caps. |
|
|
|
Refer to
→ Rep. Gr.87 for the vehicle-specific repair manual. |
Note
Torque Wrench 1783 - 2-10Nm -VAG1783- with Torque Wrench
1783 - 1/4" Drive Ratchet -VAS6234- |
Use a suitable Refrigerant Sockets -T10364- to loosen the
Schrader valve insert. Refer to
→ Fig. "" Refrigerant Sockets -T10364- for the high pressure/low
pressure side service connection valves in the refrigerant
circuit"" |
A - |
Service connection (soldered in) |
B - |
Schrader valve insert (2.4 +- 0.2 Nm) |
C - |
O-ring (belongs to the valve) |
D - |
Sealing cap with seal |
|
|
|
Special tools and workshop equipment
required
Torque Wrench 1783 - 2-10Nm -VAG1783- with Torque Wrench
1783 - 1/4" Drive Ratchet -VA ...
Other materials:
Volkswagen Touran Owners Manual. Tyre pressure
Fig. 184 Location of the tyre pressure
plate
First read and observe the introductory
information and safety warnings The correct tyre pressure for
factory-fitted tyres is shown on a sticker - applies to all-season, summer and
winter tyres. The sticker is located on the inside of the ...
Volkswagen Touran Owners Manual. Accessories and parts
First read and observe the introductory
information and safety warnings Volkswagen recommends that you seek
advice from a Volkswagen dealership before purchasing accessories, spare parts
or service fluids. For example, if the vehicle is to be retrofitted with
accessories or if parts have t ...
© 2016-2024 Copyright www.vwtouran.net | 0.0103