VW Touran manuals

Volkswagen Touran Service Manual: Flushing Not Necessary

  Note
For vehicles with an electrically-driven A/C compressor, de-energize the high voltage system before removing the A/C compressor. Refer to → Electrical System Hybrid; Rep. Gr.93.
  Discharge the refrigerant circuit.
  Remove the A/C compressor.
  Note
If a different A/C compressor is installed with a different refrigerant oil, the refrigerant circuit is to be flushed with refrigerant R134a. Refer to → Chapter "Refrigerant Circuit, Flushing (Cleaning) with Refrigerant R134a".
Electrically-driven A/C compressor:
If an electrically-driven A/C compressor is being replaced that does not have a mechanical fault (for example, a faulty circuit board), then determine how much refrigerant is in this A/C compressor.
  Note
This A/C compressor must be flushed to get all the refrigerant oil out.
The A/C compressor is flushed in the flow direction (from the low pressure side input to the high pressure side output)
So that as much refrigerant oil as possible is flushed out of the A/C compressor, the A/C compressor must be positioned so that the high pressure side output is as low as possible.
If an A/C service station without a flushing program is used, the procedure must be performed manually (evacuate, flush 3 times with at least 2 kg refrigerant each and extract refrigerant again, evacuate).
Quantity: for example 50 cm³
Pour so much refrigerant oil out of the new A/C compressor so that only the amount remains (plus 10 cm 3) that had been flushed out of the old A/C compressor beforehand. If the new original A/C compressor has for example, 200 cm3, then only pour out 140 cm3.
  Pour old refrigerant oil out of A/C compressor. Handling refrigerant oil.
  Note
In not enough refrigerant oil can be poured out from the A/C compressor to be installed, flush the new A/C compressor. After flushing, fill the A/C compressor to be installed with as much new refrigerant oil as was flushed from the replaced A/C compressor.
Mechanically Driven A/C Compressor:
  Remove oil drain plug from A/C compressor.
  To accelerate drainage of refrigerant oil, rotate compressor e.g. by way of ribbed belt pulley/clutch plate of A/C clutch for example. Does not apply to the electrically-driven A/C compressor.
  Pour old refrigerant oil out of A/C compressor. Handling refrigerant oil.
  Remove oil drain plug from original part compressor, pour out refrigerant oil and only add a quantity of fresh refrigerant oil equal to the amount poured out of the malfunctioning compressor.
  Note
If, for example, 70 cm3 of refrigerant oil has been poured out of the malfunctioning A/C compressor and 220 cm3 out of the original part A/C compressor (a small quantity of refrigerant oil remains in the A/C compressor). Fill the compressor to be installed with 70 cm 3 of refrigerant oil (use can be made of oil poured out of original part compressor).
Use different refrigerant oils and quantities for the various compressors. Refer to → Rep. Gr.87.
If a greater quantity of refrigerant oil (more than approximately 80 cm3) has been poured out of the malfunctioning compressor, the remaining refrigerant oil can also be added to the evaporator or reservoir/receiver/dryer. Refer to → Rep. Gr.87.
  Replace the restrictor depending on the vehicle.
  Assemble, evacuate and charge the refrigerant circuit.
A/C Compressor, Replacing
...

Leaks or Internal Damage, for Example Noises or No Output
  Note For vehicles with an electrically-driven A/C compressor, de-energize the high voltage system before removing the A/C compressor. Refer to &# ...

Other materials:

Volkswagen Touran Owners Manual. Stowage areas in the rear floor area
Fig. 117 Stowage areas in the floor area of the second row of seats First read and observe the introductory information and safety warnings Place the floor mat (if fitted) to one side. To open, pull the lid up from the centre   (arrow) at the rear. To close, press the lid do ...

Volkswagen Touran Owners Manual. Cigarette lighter
Fig. 123 In the front centre console: cigarette lighter First read and observe the introductory information and safety warnings  With the ignition switched on, press in the knob on the cigarette lighter  . Wait for the lighter to pop out. Pull out the cigarette li ...

© 2016-2024 Copyright www.vwtouran.net | 0.0204