Volkswagen Touran Service Manual: Working on Airbag System
WARNING
When working on the airbag system (pyrotechnic
components, Airbag Control Module -J234-, wiring), the
ground cable must be disconnected with the ignition
switched on. |
Exceptions: On vehicles with a battery in the
passenger compartment, the ignition must be switched
off. |
Then cover the negative terminal. |
After disconnecting the battery, a wait time of 10
seconds is required. |
The battery must be connected with the ignition
switched on. |
There must be no one inside the vehicle when
connecting the battery. |
Make sure in this case to keep oneself away from the
airbag deployment and belt tensioner zones. |
If the ignition is not switched on after
reconnecting the battery (the indicator lamps in the
instrument cluster do not illuminate), the ignition
(key/button) may only be switched on while sitting in
the driver's seat in the rearmost position. |
|
|
|
|
Battery Post/Terminal
WARNING
Risk of injury. Follow all Warnings and Safety
Precautions. Refer to
→ Chapter "Warnings and Safety Precautions". |
|
Caution
In order to prevent damage to the battery terminals
and battery posts, observe the following |
Never use force to attach the battery terminals by
hand. |
Do not apply grease to battery posts. |
The battery terminal clamps should be mounted so
that the battery terminal sits flush with the clamp or
protrudes out of it. |
After tightening the battery terminal clamps to the
specified torque, the threaded connections must not be
tightened again. |
|
|
|
|
Battery Safety Label
1. -
When working in the area of batteries, fire, sparks, open
flame and smoking are prohibited. Avoid sparks wh ...
General Information
WARNING
Risk of injury. Follow all Warnings and Safety
Precautions. Refer to
→ Cha ...
Other materials:
Volkswagen Touran Service Manual. Two-Part Wash Primer
Definition:
Two-Part Wash Primer -LHV 043 000 A2-
Edition 10/2010
Product Description
The two-part wash primer is a zinc chromate-free,
phenol-free and acid-free two-componen ...
Volkswagen Touran Service Manual. Flat Spots
What is a Flat Spot From Standing?
Terms like flat portion, flattening, are also used as a term
for flat spots from standing.
Flat spots from standing cause vibration, like an
incorrectly balanced wheel. It is important ...
© 2016-2024 Copyright www.vwtouran.net | 0.0069