Volkswagen Touran Service Manual: Wax Spray -D 322 100 M2
| Wax Spray -D 322 100 M2- is a long-term anti-corrosion
agent. After drying, the product forms a light brown, wax-like
film. Because of its hardness, the Wax Spray provides good
protection against mechanical stress. |
| Wax Spray -D 322 100 M2- technical application information |
| The material is primarily used in the vehicle area, but it
is also used as temporary corrosion protection for tools and
machines. |
| The Wax Spray does not corrode vehicle paint and adheres to
almost all base surfaces. |
 Note
| Before starting to apply, it is necessary to read the safety
measures and advice in the safety data sheet. |
| Even for products which are not required to be labeled by
law, the usual safety measures must be observed for chemical
emissions. |
| Bring the Wax Spray to room temperature (16 to 20 C (60.8
to 68 F). |
| Briefly shake the spray can before using. |
| The surfaces that are to be treated (underbodies, wheel
housings, insides of door) must dry and be free of grease and
dust. |
| The Wax Spray is sprayed on evenly in cross coats at a
distance of 20 to 30 cm. |
Caution
| Do not spray onto the steering, engine, driveshaft,
exhaust, catalytic converter and brake systems. |
|
|
|
|
| Base |
Wax mixture |
| Color |
Light brown/transparent |
| Film type |
Hard and wax-like |
| Density |
0.735 g/cm³ |
| Solids content |
35.4 % |
| Flashpoint/Active agent |
29 C (84.2F) |
| Flashpoint/Spray |
< -20 |
| Recommended layer
thickness |
50 mm/wet |
| Drying time |
approximately 30 minutes |
| Heat stability |
105 C (221 F) |
| Removability |
Mineral spirits |
| Processing temperature |
16 to 20 C (60.8 to 68
F) |
| Propellant gas (Aerosol) |
Propane / Butane |
| Aerosol storage |
Cool and dry, < 50 C
(122 F) |
| Hazard warning |
Highly flammable |
| Container |
500 ml |
Definition:
Wax Underbody Protection -D 316 000 A1-
Edition 01/2008
Product Description
...
Other materials:
Volkswagen Touran Owners Manual. Introduction
This chapter contains information on the following subjects:
→ Contents of the breakdown set
→ Preparations
→ Sealing and inflating tyres
→ Test after driving for 10 minutes
You can use the breakdown set (tyre mobility set) to safely seal any ty ...
Volkswagen Touran Owners Manual. How to start the engine using jump leads
Fig. 225 How to connect the jump leads
in starting vehicles without start/stop system: discharged battery Ⓐ and battery
providing assistance Ⓑ
Fig. 226 How to connect the jump leads
in starting vehicles with start/stop system: discharged battery Ⓐ and battery providing
assistance Ⓑ ...
© 2016-2026 Copyright www.vwtouran.net | 0.0244
Wax Underbody Protection -D 316 000 A1-