Volkswagen Touran Service Manual: Battery Test, Performing using Battery Tester -VAS6161-

Volkswagen Touran Service Manual / Electrical System / Battery, Starter, Generator, Cruise Control / Battery, Checking / Battery Test, Performing using Battery Tester -VAS6161-

Special tools and workshop equipment required

Battery Tester -VAS6161-

WARNING

Risk of injury. Follow all Warnings and Safety Precautions. Refer to → Chapter "Warnings and Safety Precautions".

Testing the Battery

WARNING

Do not check or charge batteries that have a visual indicator that is bright yellow. Jump starting must not be used!

There is a risk of explosion during testing, charging or jump starting.

These batteries must be replaced.

Turn off the ignition and all electrical consumers.

Battery with visual indicator, checking visual indicator. Refer to → Chapter "Battery with Visual Indicator, Checking".

Switch on the unit.

Clamp the red clamp "+" of the tester to the positive terminal.

Clamp the black clamp "-" on the tester to the negative terminal.

Note

Make sure the test clamps make good contact!

Select the following:

Check the original batteries in the warranty mode. Refer to → Chapter "Warranty Test, Performing".

Check the replacement batteries in the service mode. Refer to → Chapter "Service Test, Performing".

Note

The test is over after approximately 10 seconds.

The results of the test are output through the printer.

It is not necessary to let the tester cool down before performing the next measurement.

Battery Tester -VAS6161- Device Description

1 - Integrated printer 2 - Operating lever for the paper tray 3 - Paper slot ...

Warranty Test, Performing

WARNING Do not check or charge batteries that have a visual indicator that is bright yellow. Jump starting must not ...

Other materials:

Volkswagen Touran Owners Manual. Indicator lamps and fuel gauge
Fig. 166 In the instrument cluster: fuel gauge for petrol and diesel Fig. 167 In the instrument cluster: natural gas gauge First read and observe the introductory information and safety warnings Lit up Pointer position Possible ...

Volkswagen Touran Owners Manual. Test after driving for 10 minutes
First read and observe the introductory information and safety warnings Re-connect the tyre filler hose and check the tyre pressure on the tyre pressure monitoring display ⑥. 1.3 bar (19 psi / 130 kPa) and lower: Do not drive on! The tyre cannot be sealed sufficiently with the b ...