Volkswagen Touran Service Manual: One-Part Test Paint

Volkswagen Touran Service Manual / General Paint Information / Original Products / SprayMax System / One-Part Test Paint

Definition:

One-Part Test Paint -LLS MAX 005-, black

Edition 10/2008

Product Description

The One-Part Test Paint -LLS MAX 005- is a single-compound product from the NC resin combinations.

Properties:

Easy application (one-part material)

Dries quickly

High yield

High covering capacity

Even application

Easy to sand

Application Instructions

Application

Detecting uneven surfaces in primer- and filler base surfaces

Base Surface

Suitable base surfaces:

All primers unsanded

All applied fillers unsanded

Pre-treatment of base surfaces:

Carefully clean using the Silicone Remover -LLS MAX 007- or Silicone Remover, Long -LLS MAX 0008-.

Processing

For work safety, wear appropriate, personal protective equipment.

Latex or nitrile protective gloves, for example

Breathing mask, for example type A2/P2

Application:

Thoroughly shake the can for at least two minutes and perform a short "spray test".

Application type "coat"

Apply one misty, thin and even spray application.

The recommended dry layer thickness is 15 mm.

Spraying distance:

Maintain a distance of 20 to 25 cm.

Note

If the spraying procedure is interrupted, make sure that the valve above the spray head is empty to prevent any nozzle blockage.

Drying

Dry at +20 C (68 F) room temperature for 10 minutes. IR drying is possible with this product.

Caution

For work safety, wear appropriate, personal protective equipment.

Note the safety data sheets as well as the warnings on the label of the spray nozzle.

Shake briefly again before every subsequent spray application.

Dispose of the empty spray cans as recyclable material.

Characteristics

Solid matter content	approximately 16 %
Yield	Approximately 0.5 m² / spray can with 30 to 40 μm dry layer thickness
Note	Used only by a professional
VOC value	The EU limit for this product (product category IIB.b) in ready-to-use form is a maximum of 650 to 693 g/L volatile organic compounds. The VOC value of this product in ready-to-use form is a maximum of 260 to 277 g/can.

Storage

The guaranteed shelf life of 60 months from date of manufacture. Use no later than the date indicated on the label and store in original container at +20 C (68 F).

One-Part Anti-Corrosion Primer

Definition: One-Part Anti-Corrosion Primer -LLS MAX 003 M2-, reddish brown Edition 03/2013 Produc ...

One-Part Clear Coat

Definition: One-Part Clear Coat -LLS MAX 010- Edition 10/2008 Product Description ...

Other materials:

Volkswagen Touran Owners Manual. After changing a wheel
First read and observe the introductory information and safety warnings If needed, clean the tools then place them back in the foam rubber holder in the luggage compartment or behind the side trim on the left-hand side of the luggage compartment Stow the spare wheel, temporar ...

Volkswagen Touran Owners Manual. How to start the engine using jump leads
Fig. 225 How to connect the jump leads in starting vehicles without start/stop system: discharged battery Ⓐ and battery providing assistance Ⓑ Fig. 226 How to connect the jump leads in starting vehicles with start/stop system: discharged battery Ⓐ and battery providing assistance Ⓑ ...